Space

June 14, 2012

SpaceShipTwo flexes wings, prepares for powered flight tests

by Raphael Jaffe
Staff Writer

After a few months spent in awaiting a flight permit and evidently tweaking the design, Scaled Composites seems to be preparing the next steps in its flight test program for SpaceShipTwo.

The craft is being built for The Spaceship Co., a joint venture of Scaled and the world’s first commercial spaceline, Virgin Galactic. It will bring six passengers and its crew of two to the edge of space.

On May 30, the FAA granted an experimental launch permit to Scaled for its suborbital spacecraft, SpaceShipTwo, and its carrier aircraft, WhiteKnightTwo. This will allow flight tests using the SpaceShipTwo rocket motors.

“The Spaceship program is making steady progress, and we are all looking forward to lighting the vehicle’s rocket engine in flight for the first time,” said Doug Shane, president of Scaled.

Already, SpaceShipTwo and WhiteKnightTwo have made significant progress in their flight test program. With 82 test flights completed, WhiteKnightTwo is substantially through its test plan, while the more recently constructed SpaceShipTwo has safely completed sixteen free flights, including three that tested the vehicle’s unique “feathering” re-entry system. Additionally, ten test firings of the full-scale SpaceShipTwo rocket motor, including full duration burns, have been safely and successfully completed.

With this permit now in hand, Scaled is now authorized to press onward towards rocket-powered test flights. In preparation for those powered flights, SpaceShipTwo will soon return to flight, testing the aerodynamic performance of the spacecraft with the full weight of the rocket motor system on board. Integration of key rocket motor components, already begun during the recent downtime for routine maintenance, will continue into the autumn. Scaled expects to begin rocket powered, supersonic flights under the just-issued experimental permit toward the end of the year.

“This important milestone enables our team to progress to the rocket-powered phase of test flight, bringing us a major step closer to bringing our customers to space,” said George Whitesides, president and CEO of Virgin Galactic. “We thank the FAA for their timely issuance of this permit, and for their responsible oversight of the test program.”

SpaceShipTwo and its carrier craft, WhiteKnightTwo have been undergoing a series of flight tests at Mojave Air and Space Port. The published flight test summaries log shows a series of flights, starting April 20, 2009, with flight 4 of WhiteKnightTwo. Flights 81 and 82 took place June 2, 2012. Its objectives were: Pilot proficiency; Spoil flap evaluation; Cold soak gear extension retraction; and Copilot and brake evaluation. All objectives were met.

SpaceShipTwo tests are logged as captive carries or glide flight. The first captive carry was on March 22, 2010. The last was captive carry test 15, and took place on Oct 19, 2011. In a glide flight test, SpaceShipTwo is released and piloted back to runway 30 at Mojave Air and Space Port, Calif. The first glide test was on Oct. 10, 2010.

The last was test 16 on Sept. 29, 2011. The test objectives were: Post maintenance functional check flight; Clean release; Evaluate stability and control; Flutter expansion; Previous flutter point validation; Increased weight landing (using water ballast);and Pilot proficiency. The results were as follows: the test card called for releasing the Spaceship from WhiteKnightTwo and immediately entering a rapid descent. Upon release, the Spaceship experienced a downward pitch rate that caused a stall of the tails. The crew followed procedure, selecting the feather mode to revert to a benign condition. The crew then de-feathered and had a nominal return to base. This was great flying by the team and a good demo of feather system.

On June 1, there were four taxi run tests of SpaceShipTwo. The objective was to condition and evaluate the decelerating performance with the new higher capacity brakes. The result was that the objective was achieved. There were tests at 30 to 65 mph.




All of this week's top headlines to your email every Friday.


 
 

 

Headlines October 20, 2014

News: Navy grounds ‘Top Guns’ - The F/A-18s needs spare parts and in too many cases they’re being taken from brand new jets. This is a risk to national security and pilots’ lives.   Business: Boeing seeks revised schedule for U.S. aerial tanker - Boeing is revising its master schedule for developing the new U.S. Air Force...
 
 

News Briefs October 20, 2014

New military medical team to help with Ebola in U.S. Defense Secretary Chuck Hagel has ordered the military to prepare and train a 30-member medical support team that could provide short-term help to civilian health professionals if there are more Ebola cases in the United States. His spokesman, Rear Adm. John Kirby, says the team...
 
 

Dragon ‘fires up’ for flight

The Air Force and NATO are undergoing a cooperative development effort to upgrade the avionics and cockpit displays of AWACS aircraft belonging to the 552nd Air Control Wing at Tinker Air Force Base, Okla., and the NATO E-3 Sentrys from Geilenkirchen, Germany. The Diminishing Manufacturing Sources Replacement of Avionics for Global Operations and Navigation, otherwise...
 

 
Boeing photographs

Boeing-built X-37B successfully completes third flight

Unmanned spacecraft concludes record-setting 674-day mission   Boeing photograph A third mission of the Boeing-built X-37B Orbital Test Vehicle was completed on Oct. 17, 2014, when it landed and was recovered at Vandenberg...
 
 

Boeing concludes commercial crew space act agreement for CST-100/Atlas V

Boeing has successfully completed the final milestone of its Commercial Crew Integrated Capability Space Act Agreement with NASA. The work and testing completed under the agreement resulted in significant maturation of Boeing’s crew transportation system, including the CST-100 spacecraft and Atlas V rocket. NASA in July approved the Critical Design Review Board milestone for Boeing’...
 
 

AF to release small business research solicitations

The Air Force Small Business Innovation Research and Small Business Technology Transfer program office is set to release its fiscal year 2015 list of topics Oct. 22, on the SBIR/STTR website.  Small businesses and research institutions with expertise to address the topics’ technology challenges are encouraged to submit proposals. During 2014, the Defense Department SBIR...
 




0 Comments


Be the first to comment!


Leave a Reply

Your email address will not be published. Required fields are marked *

You may use these HTML tags and attributes: <a href="" title=""> <abbr title=""> <acronym title=""> <b> <blockquote cite=""> <cite> <code> <del datetime=""> <em> <i> <q cite=""> <strike> <strong>