Defense

August 28, 2012

Device boosts Navy’s ability to inspect, repair aircraft engines

by Rachel Lytle
Patuxent River, Md.

The Naval Air Systems Command announced Aug. 27 that it has developed a device that is doing for aircraft inspections what colonoscopies have done for cancer detection.

Used to inspect interior engine components and airframes for cracks, corrosion and other debris that can harm Navy and Marine Corps aircraft, the Common Video Borescope Set, or CVBS, is scheduled for “initial operating capability” in September when units will be delivered to Sailors and Marines.

“Compressor blades rotating in an aircraft engine power naval aviation on a daily basis, but anything accidentally entering the engine intake can create nicks and chip the blades,” said Lt. Cmdr. Francini Clemmons, assistant deputy program manager for nondestructive inspection equipment, who oversees the CVBS project for the Aviation Support Equipment Program Office. “Instead of taking the engine apart, the video borescope allows inspectors to look into the jet engine, saving time and energy.”

The borescope will not only bring commonality to the fleet and revolutionize the way the Department of the Navy inspects aircraft and engines but it will also provide real-time digital images and video for examination, Clemmons added. “The CVBS can be likened to a colon screening, but ours is kinder and gentler to the aircraft,” he said. “It will instantly increase the efficiency and effectiveness of our inspection procedures.”

The CVBS is a naval modified version of a commercial-off-the-shelf product and will support all aircraft platforms requiring video borescope inspections of their airframes and engines. It offers many advantages over its varied predecessors, officials said.

While previous borescopes in the naval inventory detected engine debris with a rigid probe and generated low-quality, black-and-white pictures, the CVBS has a 2-meter long, flexible, insertion tube that captures photos and video images on a 3.7-inch color screen. Technicians will use a joystick to maneuver the device’s insertion tube, giving them a 360-degree view of hard-to-see places.

All CVBS handsets are capable of defect measurement and offer two hours of battery operation. The CVBS Type V variant comes with a working channel and tools that can retrieve debris.

At 3.74 pounds, the CVBS is also less expensive and lighter than its 30-pound predecessors. Many of the 27 varieties of legacy borescope systems could cost as much as $30,000 per unit, Clemmons said. The Navy plans to buy 960 CVBS units at an approximate cost of $15,000 each.

Marc Donohue, nondestructive inspection Common Support Equipment integrated program team lead for PMA-260, said he has received positive feedback from both fleet and fleet support team personnel who have used the CVBS during the test and evaluation phase.

“The unit is ruggedized, highly portable and over 80 percent lighter than many of the legacy units it replaces,” Donohue said. “The CVBS improves equipment survivability and reliability while providing enhanced capability. The program achieves cost-wise readiness at less than 50 percent of the CVBS program’s cost objective and at only 31 percent of the cost of sustaining legacy system requirements.”

The Aviation Support Equipment Program Office manages the procurement, development and fielding of common ground support equipment and automatic test equipment, which support every type, model and series of aircraft within the Naval Aviation Enterprise.

 




All of this week's top headlines to your email every Friday.


 
 

 
Army photograph by C. Todd Lopez

Army to launch cruise missile-detecting aerostat at Aberdeen Proving Ground

Army photograph by C. Todd Lopez The Army plans to launch an aerostat, part of the “Joint Land Attack Cruise Missile Defense Elevated Netted Sensor,” in late December 2014. The JLENS aerostat will be tethered to the...
 
 
Air Force photograph by SrA. Jordan Castelan

AF delivers Iraqi F-16s for training in US

Air Force photograph by SrA. Jordan Castelan Iraqi air force captain Hama conducts preflight inspections while inside a new to service Iraqi F-16 Fighting Falcon Dec. 17, 2014, located at the nearby Tucson International Airport...
 
 
Air Force photograph by SSgt. Derek VanHorn

Short-notice: A new way to exercise

Air Force photograph by SSgt. Derek VanHorn Airmen from Kadena Air Base, Japan, prepare for an aeromedical evacuation exercise on a KC-135 Stratotanker Dec. 5, 2014, at Misawa Air Base, Japan. The operation was executed in supp...
 

 
Lockheed Martin photograph by Andy Wolfe

Japan, Australia to provide F-35 maintenance sites in Pacific region

Lockheed Martin photograph by Andy Wolfe An F-35C Lightning II joint strike fighter carrier variant prepares to launch from the aircraft carrier USS Nimitz in the Pacific Ocean, Nov. 6, 2014. Japan and Australia will be sharing...
 
 
Air Force photograph by SrA. Maeson L. Elleman

Hanscom working to provide 5th, 4th gen aircraft common tactical picture

Air Force photograph by SrA. Maeson L. Elleman A U.S. Air Force F-15C Eagle taxis for takeoff on Kadena Air Base, Japan, Sept. 16, 2014. The Space, Aerial and Nuclear Networks Division at Hanscom Air Force Base, Mass., is worki...
 
 
Air Force photograph by SSgt. Staci Miller

Australian F-35 lands at new home

Air Force photograph by SSgt. Staci Miller The first Royal Australian Air Force F-35A Lightning II jet arrives at Luke Air Force Bas, Ariz., Dec. 18, 2014. The jet’s arrival marks the first international partner F-35 to a...
 




0 Comments


Be the first to comment!


Leave a Reply

Your email address will not be published. Required fields are marked *

You may use these HTML tags and attributes: <a href="" title=""> <abbr title=""> <acronym title=""> <b> <blockquote cite=""> <cite> <code> <del datetime=""> <em> <i> <q cite=""> <strike> <strong>