Defense

November 18, 2013

U-2 Program Office helps eliminate DCS

Thanks to the U-2 Program Office at Robins Air Force Base, Ga., Air Force pilots flying the “Dragon Lady” no longer experience decompression sickness during their high-altitude flights.

Commonly referred to as DCS, decompression sickness is caused by the formation of nitrogen bubbles in the blood and tissue following a sudden drop of air pressure.

For U-2 pilots, who routinely fly missions above 70,000 feet, this has been a major concern.

“Our pilots were seeing an increased number of DCS incidents due to long missions,” said Col. Fred Kennedy, Command and Control, Intelligence, Surveillance and Reconnaissance Division chief. “Air Force senior leaders became aware of the problem, and made fixing it their†number one†priority for our program.”

The fix – dubbed the Cabin Altitude Reduction Effort, or CARE, program – beefs up the U-2’s structure, replaces the legacy cockpit pressure regulator and safety valve, and includes modifications to the engine bleed schedule. That permits engineers to nearly double the cockpit pressure experienced by a U-2 pilot, from 4.4 pounds per square inch to more than 8 psi.

“What our folks have done is to drop the apparent altitude in the cockpit from 29,500 feet to 15,000 feet, roughly the difference between Mount Everest and Pikes Peak,” said Kennedy. “CARE basically eliminates the risk of DCS and allows our U-2 pilots – who might otherwise have been removed from flying status – to keep flying.”

A total of 27 U-2 airframes have been outfitted with CARE, ahead of schedule and under cost. The total outlay for the program was just $8.7 million.

To date, there have been no reported DCS incidents since the modifications.

“This is a big deal for the U-2 community,” said Kennedy. “Healthy pilots mean more missions and more extraordinary ISR capability for our war fighters.”




All of this week's top headlines to your email every Friday.


 
 

 
Air Force photograph by Capt. Tania Bryan

NORTHERN EDGE provides environment for testing new capabilities

Air Force photograph by Capt. Tania Bryan Aircraft from test and evaluation squadrons across the Air Force line up on the Joint Base Elmendorf-Richardson flightline. Northern Edge is Alaska’s premier joint training exercise d...
 
 
Air Force photograph by Alex R. Lloyd

Ogden ALC completes test flight after F-35B STOVL mods

Air Force photograph by Alex R. Lloyd A Marine Corps F-35B STOVL Joint Strike Fighter aircraft completes its first-ever check flight at Hill AFB, Utah, June 18, 2015. The aircraft was undergoing a functional check flight follow...
 
 
navy-tomahawk

USS Anzio conducts Tomahawk test launch

Navy photograph   A Tomahawk land-attack cruise missile is fired from the Ticonderoga-class guided-missile cruiser USS Anzio (CG 68) during a missile exercise June 25 off the coast of Florida.   The test proved that the ...
 

 
Army photograph by David Vergun

Innovative system links Army networks with allies, agencies

Army photograph by David Vergun Joe Marinich, participating in the Joint Users Interoperability Communications Exercise at Aberdeen Proving Ground, Md., June 24, 2015, uses a Multimedia Gateway to allow the Federal Emergency Ma...
 
 
Air Force photograph by SSgt. William Banton

Raptors bring intimidation to exercise Northern Edge

Air Force photograph by SSgt. William Banton An F-22 Raptor from the 525 Fighter Squadron, returns from a mission during exercise Northern Edge 2015 at Joint Base Elmendorf-Richardson, Alaska, June 18, 2015. Northern Edge is Al...
 
 
Army photograph

Army puts Gray Eagle, One System Remote Video Terminal through test

Army photograph The MQ-1C Gray Eagle, the Army’s largest unmanned aircraft system in the inventory, recently underwent follow on test and evaluation, which culminated June 14 at the National Training Center in Fort Irwin,...
 




0 Comments


Be the first to comment!


Leave a Reply

Your email address will not be published. Required fields are marked *

You may use these HTML tags and attributes: <a href="" title=""> <abbr title=""> <acronym title=""> <b> <blockquote cite=""> <cite> <code> <del datetime=""> <em> <i> <q cite=""> <s> <strike> <strong>